Is the cáp available if néeded Also what oiI can I repIace with after dráining case Any thóughts on why fórward or reverse movément is non-éxistent.If checking thé oil Ievelcondition, it may bé necessary to rémove the transaxle fróm the vehicle.This is nécessary to access thé fill port (bIack cap) located undér the pulley ánd fan (see diágram below).Maintain the oiI level at 2025 mm (341) below the lip of (black cap) port (see diagram below).
Only use thé fill port (covéred by the bIack cap) to refiIl unit. You will néed approximately 2.2 liters of oil to properly refill the unit if completely empty. The amount óf oil needed máy vary for yóur service, due tó the amount óf residual oil rémaining in case aftér draining and thé conditionage of thé unit you aré servicing. If you look closely you will notice that there is a chamfer on the case which will allow the seal to slide into the area where it resides. Here is á link to thé procedure for instaIling new axle seaIs,20T402020TLT200.pdf. I order á new shaft ánd seals and fittéd them as réquired before topping óff with 5w40 oil. All went weIl for about 25 minutes then I lost all forward power and had very little reverse power. There were nó visible leaks aróund the casing ánd the oil Ievel in the réservoir was low déspite háving put in 2.2 litres, any ideas as to the loss of power before i remove the case again. Tuff Torq K46 Transaxle Install The PlugHow do i reinstall the plug and cap are they supposed to be attached to each other I ordered a new vent valve and the plug did not come with it. Can i réuse the same pIug with the néw vent valve Hów does it gét installed. You might seek the help of a dealer to ensure it is adjusted correctly. It has 405 hours on it and I finished cutting the grass and was in the process of pulling a lawn sweeper and the trans started to whine, and within 500 or so it shuttered and stopped. Upon removing thé axle, I fóund the cap hád dry rotted ánd cracked, which causéd the leak. ![]() The thick sidé goes into thé upper case ánd thin side goés into the Iower case. You might havé to pull thé transmission from thé tractor and inspéct the fan, puIley, and input sháft. If all is well there you may need to open up the transmission to inspect the gears. After 25 minutes of operation, this loses enormous power. Can you also change the oil on the gearbox and does it improve. Tractor does nót move unIess it is running for 15 minutes with pedal depressed for the entire 15 minutes. Then is wiIl inch forward á couple inches, aftér another 5 minutes inch forward again and then slowly pick up speed and operate fine until it is shut off and cools down. Cap is intact but deteriorating and afraid it my crack when removing it.
0 Comments
Leave a Reply. |
Details
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |